DreamLine DL-6193C-01 Installationsanleitung Seite 1

QWALL – 5 & SlimLine Shower Base Kit ACRYLIC SHOWER WALL AND SHOWER BASE KIT INSTALLATION INSTRUCTIONS IMPORTANT DreamLineTM reserves the righ

Ver. 1, Rev. 1 9 9. Determine the position of both Side panels (01). NOTE: a) The narrow edge of the Side panel fits behind the corner cover and

Ver. 1, Rev. 1 10 Fig. 13 11. Take exact measurements of the fixture on the wall: • from the 1” (one inch) line in the cor

Ver. 1, Rev. 1 11 12. Determine which Side panel (01) will be installed on the side wall with the fixture. Mark the fixture location on the Side panel

Ver. 1, Rev. 1 12Acrylic Back Panel and Side Panel Installation Instruction 14. Attach the Center cover (10) vertically at the center point along the

Ver. 1, Rev. 1 13 Fig. 19 16. Attach the Corner cover (02) to the corner of the shower and mark the drilling holes thro

Ver. 1, Rev. 1 14 Fig. 21 ATTENTION: 17. Apply the sealant to the entire surface of the reverse side of the Back panel (0

Ver. 1, Rev. 1 15 18. Slide the right edge of the left Back panel (09) all the way behind the Center cover (10) and push the Back panel against the wa

Ver. 1, Rev. 1 16 19. Mount the Corner cover (02) to the corner of the shower using the Countersunk screws ST4.2×30 (07). Do not fully tighten the scr

Ver. 1, Rev. 1 17 21. Slide the narrow edge of the Side panel (01) behind the Corner cover (02). Align trimmed edge of the Side panel (from Step. 9)

Ver. 1, Rev. 1 18 23. Once all panels are aligned, fasten tight the Corner cover (02) to secure the Side panels (01) and Back panels (09). Cover the s

Ver. 1, Rev. 1 QWALL – 5.2 (2 Back Panels) SHOWER ACRYLIC WALL INSTALLATION INSTRUCTIONS IMPORTANT DreamLineTM reserves the right to alter, modify

Ver. 1, Rev. 1 19 ATTENTION; Prior to the next step, please be sure the part of the wall for installation of the Decorative edge molding (03) is clea

Ver. 1, Rev. 1 20Glass Shelves Installation Instruction 27. Determine the desired height for the Glass shelves (05) and mark the locations on the wa

Ver. 1, Rev. 1 21 29. Mount the Shelf brackets (04) to the wall using the Countersunk screws ST4.2×30 (07). NOTE: the padded set screw of the Glass b

Ver. 1, Rev. 1 22 Product maintenance To insure long lasting life for your acrylic back walls, wipe them off after each use with a soft cloth. To

SLIMLINE SHOWER BASE SHOWER BASE DIMENSIONS AND INSTALLATION INSTRUCTIONS IMPORTANT DreamLineTM reserves the right to alter, modify or r

“SLIMLINE SHOWER BASE” Ver.5 Rev.5 06/2015 2 Preparation 1. Prior to installation, examine all boxes and packages for shipping damage

“SLIMLINE SHOWER BASE” Ver.5 Rev.5 06/2015 3 SINGLE THRESHOLD SHOWER BASE Center Drain Configuration MODEL SPECIFICATION D (in) W (in) D1

“SLIMLINE SHOWER BASE” Ver.5 Rev.5 06/2015 4 SINGLE THRESHOLD SHOWER BASE Left-Hand Drain Configuration

“SLIMLINE SHOWER BASE” Ver.5 Rev.5 06/2015 5 SINGLE THRESHOLD SHOWER BASE Right-Hand Drain Configuration

“SLIMLINE SHOWER BASE” Ver.5 Rev.5 06/2015 6 NEO ANGLE SHOWER BASE MODEL SPECIFICATION W (in) A (in) B (in) C (in) D

Ver. 1, Rev. 1 2Preparation 1. After opening all boxes and packages, read this introduction carefully. Check that all of the needed parts are inclu

“SLIMLINE SHOWER BASE” Ver.5 Rev.5 06/2015 7 QUARTER ROUND SHOWER BASE MODEL SPECIFICATION W (in) C (

“SLIMLINE SHOWER BASE” Ver.5 Rev.5 06/2015 8 DOUBLE THRESHOLD SHOWER BASE Corner Drain Configuration MODEL SPECIFICATION W (in) C (

“SLIMLINE SHOWER BASE” Ver.5 Rev.5 06/2015 9 DOUBLE THRESHOLD SHOWER BASE Left-Hand Drain Configuration MODEL SPECIFICATION D (i

“SLIMLINE SHOWER BASE” Ver.5 Rev.5 06/2015 10 DOUBLE THRESHOLD SHOWER BASE Right-Hand Drain Configuration MODEL SPECIFICA

“SLIMLINE SHOWER BASE” Ver.5 Rev.5 06/2015 11 Shower Base Cross Section Diagram Finished Wall Cement board Shower Base

“SLIMLINE SHOWER BASE” Ver.5 Rev.5 06/2015 12 Shower Base Installation - Preparation 1. Ensure that the floor and the studs are at right angles.

“SLIMLINE SHOWER BASE” Ver.5 Rev.5 06/2015 13 2. Install the shower drain (NOT INCLUDED) according to the drain installation manual (supplied wit

“SLIMLINE SHOWER BASE” Ver.5 Rev.5 06/2015 14 4. Level the tray and place marks on the studs above the upper edge of the tile flange. See F

“SLIMLINE SHOWER BASE” Ver.5 Rev.5 06/2015 15 6. After the bedding material has been poured and before it sets, place the shower base

“SLIMLINE SHOWER BASE” Ver.5 Rev.5 06/2015 16 Product maintenance To ensure long lasting life for your acrylic back walls, wi

Ver. 1, Rev. 1 3Detailed Diagram of Acrylic Shower Wall Components 10958"- 62"46"- 50"56784213 Packing List 01 Side panel 2pcs

DREAMLINE™ EXCLUSIVE LIMITED WARRANTY AS OF MAY 6, 2013 This warranty extends only to the original owner/end‐user for household use only and is not

TEL: 866-731-2244 FAX: 866-857-3638 WWW.BATHAUTHORITY.COM For more information on DreamLineTM Shower Bases please

Ver. 1, Rev. 1 4Preparation for Installation of Back Panel 1. Place a mark on the walls at a distance of 1” (one inch) from the corner and draw a p

Ver. 1, Rev. 1 5 3. Divide the measurement “W” by two and place a mark in the center of the back wall and from there draw a plumb vertical line from

Ver. 1, Rev. 1 6 5. Measure the Back Panel (09). Width of the Back Panel has to be less than or equal to the distance between the center line and the

Ver. 1, Rev. 1 7 7. Place the Back Panel (09) onto a flat piece of plywood or particle board. Use a sharp industrial knife and a T-square to score al

Ver. 1, Rev. 1 8Preparation for Installation of Side Panels ATTENTION: See Fig. 9 for details. Fig. 9 8. Measure the side wa